Bürkert
Servostyrd 2/2-vägs membranventil
Typ 5282 / Artikelnr. 134453
Artikelbeskrivning
Ventiltyp 5282 är en servostyrd membranventil. För att ventilen ska fungera korrekt behövs alltid ett minimidifferenstryck. Det finns olika membranmaterial och verkningssätt att välja bland, beroende på användningsområdet. Standardventilhuset i mässing uppfyller alla europeiska krav för dricksvatten. Vårt utbud av ventilhus kompletteras av utföranden i rostfritt stål och gjutjärn. 3/2-vägs pilotventilens verkningssätt kan ställas om från NC till NO genom att pilotventilen vrids på armaturen. Magnetspolarna tätas med epoxi med hög kemisk beständighet. För idrifttagning och test är ventilen 5282 utrustad med en manuell manövreringsfunktion. I kombination med en stickkontakt enligt DIN EN 175301-803 form A och ett hus av rostfritt stål uppfylls kraven enligt NEMA 4X.
- Statistiskt varunummer
- 84818079
- Land
- DE
Tekniska specifikationer
Namn |
Värde |
Enhet |
|---|---|---|
| Type | 5282 | |
| Operation | servo-controlled | |
| Actuator type | Pivot | |
| Main valve operating principle | Diaphragm valve | |
| Switch function | on/off | |
| Media separation | Yes | |
| Valve function | A - normally closed - inlet port 1 (P/NC) | |
| Fluidic port connection number | 2 | |
| Valve function number of switching positions | 2 | |
| Valve function manual actuation | Yes | |
| Valve function manual actuation type | Key button | |
| Valve function manual actuation stop | Yes | |
| Nominal pressure min | 0,2 | bar |
| Nominal pressure max (liquid) | 10 | bar |
| Main valve orifice 1 (P) (mm) | 50 | mm |
| Main valve orifice 1 (inch) | 2 inch | |
| Kv value (water) | 40 | m3/h |
| QNn value (gas) | 43.000 | l/min |
| Main valve wetted material | Brass | |
| Port connection 1 type | Inner thread | |
| Port connection 1 thread type | G | |
| Port connection 1 thread marking | 2 | |
| Port connection 2 type | Inner thread | |
| Port connection 2 thread type | G | |
| Port connection 2 thread marking | 2 | |
| Pilot control material medium-contacting | Brass | |
| Seat seal material category | Elastomer | |
| Seat seal material | NBR (Nitrile rubber) | |
| Sealing toward outside material | NBR (Nitrile rubber) | |
| Temperature environment max | 55 | °C |
| Temperature medium min | 0 | °C |
| Temperature medium max | 80 | °C |
| Voltage / rated voltage | 230 | V |
| Voltage / rated voltage | 230 | V |
| Voltage tolerance negative | 10 | % |
| Voltage tolerance positive | 10 | % |
| Voltage frequency | 50/60 | Hz |
| AC voltage | Yes | |
| DC voltage | No | |
| Battery voltage | No | |
| Rated power consumption | 8 | W |
| inrush power consumption AC | 30 | V·A |
| Rated power AC | 15 | V·A |
| Electrical connection sort | Plug pattern form A according to DIN EN 175301-803 | |
| Electrical connection number of contacts | 2 + Grounding conductor | |
| Electrical connection position | top | |
| Electrical connection polarity | Irrelevant | |
| Protection type (IP max. with suitable connector) | IP65 | |
| Coil type | block bolted | |
| Coil insulation material (encasement) | Epoxy | |
| Coil wiring overvoltage protection | without | |
| Coil wiring rectifier | No | |
| Coil wiring polarity recovery diode | No | |
| Thermal insulation class of the actuator | H | |
| Nominal operation/Duty cycle | 100 | % |
| Switch time open min | 100 | ms |
| Switch time open max. | 800 | ms |
| Switch time close min | 1.000 | ms |
| Switch time close max. | 4.000 | ms |
| Valve setting opening time | Yes | |
| Valve setting closing time | Yes | |
| Back-pressure-resistant version | No | |
| Vacuum version | No | |
| Analysis version | No | |
| Oxygen version | No | |
| Oil burner valve | No | |
| Steam version | No | |
| Pilot control orifice (mm) | 2 | mm |
| Pilot control seal material | NBR (Nitrile rubber) | |
| Low-noise version | No | |
| Main valve with integrated screen | No | |
| Installation length | 164 | mm |
| Valve construction | Valve complete | |
| Vikt | 5,035000 | kg |
Kan kombineras med
Applikationer & Verktyg
Ladda ner
Datablad
Beskrivning |
Filstorlek |
Språk / Land |
|
|---|---|---|---|
|
Type 5282 data sheet | servo-assisted solenoid valve with servo diaphragm | 1,3 MB | EN / EU |
|
|
Type 5282 data sheet | servo-assisted solenoid valve with servo diaphragm [US units] | 239,9 kB | EN / US |
|
|
Typ 5282 Datenblatt | vorgesteuertes Magnetventil mit Servomembrane | 1,2 MB | DE / DE |
Manual
Beskrivning |
Filstorlek |
Språk / Land |
|
|---|---|---|---|
|
|
Operating Instructions Type 0780 | ATEX approval | 1,5 MB | EN,FR,DE / EU |
|
|
Operating Instructions Type 5282 | 2-way solenoid valve, direct-acting | 496 kB | EN / EU |
|
|
Operating Instructions Type 5282 | 2/2-way Solenoid Valve | 1,1 MB | EN / EU |
|
|
Operating Instructions Type ACP016 | Solenoid coil ACP016, II 2G/D Ex approval | 1,5 MB | EN / EU |
|
|
Bedienungsanleitung Typ 5282 | 2/2-Wege-Magnetventil | 1,1 MB | DE / DE |
|
|
Bedienungsanleitung Typ ACP016 | Magnetspule ACP016, II 2G/D Ex Zulassung | 1,5 MB | DE / DE |
|
|
Manuel d'utilisation Type 5282 | Électrovanne 2/2 voies | 1,1 MB | FR / FR |
|
|
Manuel d'utilisation Type ACP016 | Bobine magnétique ACP016, homologation II 2G/D Ex | 1,6 MB | FR / FR |
EU-försäkran
Beskrivning |
Filstorlek |
Språk / Land |
|
|---|---|---|---|
|
|
EU-DoC|EU Declaration | 3 MB | EN,FR,DE |
Funktionell modell
Beskrivning |
Filstorlek |
Språk / Land |
|
|---|---|---|---|
|
|
3D-Animation - 5282 | 2,9 MB | EN |
Informationsblad och kataloger
Beskrivning |
Filstorlek |
Språk / Land |
|
|---|---|---|---|
|
|
4,3 MB | EU | |
|
|
723 kB | AF | |
|
|
Media separation ensures continous and safe processes | 599 kB | EN / EU |
|
|
Solenoid valves for safety in your plant | 786,8 kB | EN / EU |